Daihatsu experimenting with hydrazine as a fuel cell possibility

Hydrazine, not hydrogen, and it has some very interesting implications for the development of fuel cells.

Like it or not, every major auto manufacturer is working with hydrogen fuel cells - and there's a reason for that. Hydrogen is extremely energy dense, available everywhere in the world (or universe, for that matter), and can be used in place of heavier, less energy dense batteries in automotive applications for electric vehicles.

With all of that, hydrogen has some down-sides. Daihatsu thinks it has found a solution to eliminate those downers and make fuel cells cheaper and their fuel more safe in storage and transport. They showed off their ideas in Tokyo with their FC ShoCase concept vehicle.

The ShoCase itself is a pure concept that will not ever likely make it to production. It was shown as part of the company's Kei line of ultra-small vehicles for urban use. These vehicles sell well in Japan and Daihatsu, as the country's oldest automaker, is a small, but innovative and proud company. Since 2007, they've been working with an alternative fuel concept for fuel cell vehicles.

While the rest of the world's carmakers, including Daihatsu's part-owner Toyota, are perfecting hydrogen fuel cells, Daihatsu is instead working with hydrazine.

If you're familiar with hydrazine, it's likely because you're familiar with polymer foams, rocket fuels, or the manufacture of air bags or pharmaceuticals. Or perhaps with nuclear power plant operations. This chemical is used in dozens of applications for which some 260,000 tons are produced annually. In its purest form, it's extremely toxic, but it's most often used in solution. Hydrazine is comparable to ammonia with a chemical signature of N2H4.

So why use it in place of hydrogen for fuel cells? Simple. Everything bad about fuel cells becomes good with hydrazine.

Hydrogen's biggest dilemma in fuel cell use is its requirement that it be bathed in highly acidic electrolyte solution in order to facilitate the proton exchanges necessary to give off that coveted electron to run through an electrical circuit. This acidic chemistry means that most metals will not last long and thus cannot be used as a catalyst. Top choices are narrow and usually expensive, with most using platinum as their choice. This is what makes fuel cells expensive, potentially dangerous if ruptured, and relatively hard to build. Add to that the highly volatile nature of hydrogen itself, one of the most flammable gases known, and there are some obvious obstacles to overcome with hydrogen fuel cells.

Hydrazine, on the other hand, has none of those problems. Hydrazine works best in a fuel cell that is aklaline, rather than acidic, and so just about any cheap, readily available metal can be used as a catalyst. Daihatsu has tried both cobalt and nickel with success. What's more, if the fuel cell is ruptured, nothing inside need be toxic to the environment or people, making it much safer.

But wait, isn't hydrazine toxic? Only if it's in its pure form. Daihatsu has instead come up with a fuel tank for storing it that fixes the hydrazine hydrate solution to the fuel tank itself, using a polymer coating, which minimizes spill potential and does not hinder fuel delivery. It should also be mentioned that hydrazine hydrate is a liquid fuel that can be distributed in the same way gasoline is today, with the same general safety precautions, but none of the flammable fume worries gasoline has. It can also be synthetically produced without petroleum and gives off no CO2 or toxins once used (it releases only water and nitrogen from the tailpipe).

So far, engineers at Daihatsu have managed to produce an output density of 0.50 watts per centimeter squared (W/cm2), which is comparable to current hydrogen fuel cells.

Interestingly, few in the automotive press have noticed this little entry from Japan's most venerable car maker. Most seem to have been instead interested only in the ShoCase concept car rather than its highly innovative workings under the hood (if it had a hood). It's possible that Daihatsu has made the breakthrough that hydrogen fuel cell developers have been pining after for years.